Preclinical studies suggest that the biochemical effects of N-(phosphonacetyl)-L-aspartate (PALA), an inhibitor of aspartate carbamoyltransferase (ACTase), may increase the metabolic activation of 5-fluorouracil (5-FU) and enhance its cytotoxicity through both RNA- and DNA-directed mechanisms. In this Phase I trial, 22 evaluable patients with adenocarcinoma of the gastrointestinal tract were entered at escalating doses of 5-FU starting at 1150 mg/m2/day given as a concurrent 72-h i.v. infusion with a fixed dose of leucovorin (LCV), 500 mg/m2/day. The dose of 5-FU was escalated within patients according to individual tolerance, and then PALA at 250 mg/m2 was added 24 h prior to the initiation of the 5-FU/LCV infusion of the subsequent cycle. Dose-limiting mucositis and myelosuppression occurred during the initial cycle in 3 of 5 patients treated with 2300 mg/m2/day 5-FU; therefore, the recommended dose of 5-FU with concurrent LCV is 2000 mg/m2/day. Twenty-seven additional patients were then treated with escalating doses of PALA ranging from 375 to 2848 mg/m2, i.v., followed 24 h later by 2000 mg/m2/day 5-FU with high-dose LCV. Dose-limiting mucositis and myelosuppression occurred during the initial cycle in 2 of 3 patients entered at 2848 mg/m2 PALA. Dose-limiting mucositis and skin rash ultimately required both PALA and 5-FU dose reductions in 4 of 6 patients treated with 1899 mg/m2 PALA. Toxicity was similar, however, in patients receiving PALA at doses ranging from 375 to 1266 mg/m2. The mean steady-state plasma concentration of 5-FU at 2000 mg/m2/day was 6.5 +/- 0.9 microM; patients with 5-FU levels > 9 microM had a significantly higher incidence of serious gastrointestinal and hematological toxicity. Compared to each patient's own baseline, a significant trend for decreasing ACTase activity with increasing PALA dose was evident using cytosol isolated from peripheral blood mononuclear cells 24 h after PALA treatment (P2 = 0.01). PALA < or = 844 mg/m2 failed to appreciably inhibit ACTase activity at 24 h in most patients; furthermore, a decrease in ACTase activity by > 50% from baseline was seen in only 29% of cycles. More consistent inhibition of ACTase activity was seen with PALA > or = 1266 mg/m2. Even with the highest PALA doses, however, ACTase activity returned to baseline by 96 h in most patients.(ABSTRACT TRUNCATED AT 400 WORDS)